Cart
TRAP-KLEEN


Material Safety Data Sheet

U.S. Department of Labor

May be used to comply with

OSHAs Hazard Communication Standard, 29 CFR 1910 1200. Standard must be consulted for specific requirements.

Occupational Safety and Health Administration

(Non-Mandatory Form)

Form Approved

OMB No. 1218-0072

IDENTITY (as Used on Label and List)

TRAP-KLEEN

Note: Blank spaces are not permitted. If any item is not
applicable or no information is available, the space
must be marked to indicate that.

Section I

Manufacturer's name 

UNIT CHEMICAL CORPORATION

Emergency Telephone Number (800) 879-8648

Address (Number, Street, City, State and ZIP Code)

 7360 COMMERCIAL WAY

Telephone Number for Information (702) 564-6454 or (702) 564-6455

 HENDERSON, NV 89 015

Date Prepared  DECEMBER 1, 2005

Signature of Preparer (optional)

Section II Hazardous Ingredients/Identity Information

Hazardous Components (Specific Chemical Identity, Common Name(s))


OSHA PEL


ACGIH TLV

Other Limits Recommended


% (optional)

SILICIC ACID, DISODIUM SALT (SODIUM METASILICATE)  CAS #6834-92-0

Section III Physical/Chemical Characteristics

Boiling Point N/A

Specific Gravity (H20 = 1)

N/A

Vapor Pressure (mm Hg)  N/A

Melting Point

UNKNOWN

Vapor Density (AIR = 1)  N/A

Evaporation Rate (Butyl Acetate = 1)

N/A

Solubility in Water  COMPLETE

Appearance and Odor ORANGE GRANULES WITH PINE TYPE ODOR (TURNS GREEN WITH WATER)

Section IV Fire and Explosion Hazard Data

Flash Point (Method Used)  NONE (NON-FLAMMABLE)

Flammable Limits

LEL NONE

UEL NONE

Extinguishing Media NONE

Special Fire Fighting Procedures NONE

Unusual Fire and Explosion Hazards NONE

(Reproduce locally)  OSHA 174 Sept. 1985



Section V Reactivity Data

Stability

Unstable

Conditions to Avoid

Stable

X

FLAMMABLE HYDROGEN GAS MAY BE PRODUCED ON PROLONGED CONTACT WITH METALS SUCH AS ALUMINUM, TIN, LEAD, AND ZINC.

Incompatibility (Materials to Avoid)  CONCENTRATED ACIDS

Hazardous Decomposition or Byproducts NONE

Hazardous
Polymerization

May Occur

Conditions to Avoid

Will Not Occur

X

 NONE

Section VI Health Hazard Data

Route(s) of Entry

Inhalation?  NO

Skin?  NO

Ingestion?  YES

Health Hazards (Acute and Chronic) 

EYES CONTACT - CORROSIVE - CAN CAUSE BURNS: FLUSH EYES IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. CALL A PHYSICIAN.

SKIN CONTACT - CORROSIVE - CAN CAUSE BURNS: PROLONGED OR REPEATED CONTACT WITH SKIN CAUSES IRRITATION. WASH SKIN OFF WITH WATER.

INGESTION: IF SWALLOWED, DO NOT INDUCE VOMITING. GIVE LARGE QUANTITIES OF WATER. GIVE AT LEAST ONE OUNCE OF VINEGAR IN EQUAL AMOUNTS OF WATER. CONSULT PHYSICIAN IMMEDIATELY.

INHALATION - CORROSIVE - CHANCE OF CAUSING BURNS TO RESPIRATORY TRACT BY INHALING GRANULES SLIGHT.

Carcinogenicity 

NTP?  NO

IARC Monographs?  NO

OSHA Regulated? NO

Signs and Symptoms of Exposure  BURNING AND/OR REDNESS OF SKIN OR EYES

Medical Conditions
Generally Aggravated by Exposure  - HAVE NOT BEEN ESTABLISHED

Emergency and First Aid Procedures ABOVE UNDER HEALTH HAZARDS

Section VII Precautions for Safe Handling and Use

Steps to Be Taken in Case Material Is Released or Spilled

SWEEP, SCOOP, OR VACUUM UP AND STORE DISCHARGED MATERIAL. FLUSH RESIDUE WITH WATER.

Waste Disposal Method NEUTRALIZE WITH DILUTE ACID SUCH AS VINEGAR OR CITRIC ACID AND LANDFILL SOLIDS ACCORDING TO LOCAL, STATE, AND FEDERAL REGULATIONS.

Precautions to Be Taken in Handling and Storing STORE AT TEMPERATURES BETWEEN 0oF AND 110oF

Other Precautions WEAR GLOVES AND FACE SHIELD

Section VII Control Measures

Respiratory Protection (Specify Type) NONE REQUIRED

Ventilation

Local Exhaust  NONE REQUIRED

Special NONE REQUIRED

Mechanical (General)  NONE REQUIRED

Other FUMES WONT CAUSE RESPIRATORY PROB.

Protective Gloves RUBBER WHERE CONTACT LIKELY

Eye Protection GOGGLES AND/OR FACE SHIELD

Other Protective Clothing or Equipment  SAFETY SHOWER AND/OR EYEWASH FOUNTAIN SHOULD BE AVAILABLE

Work/Hygienic Practices   WASH THOROUGHLY AFTER HANDLING. WASH CONTAMINATED CLOTHING BEFORE RE-USE

Sort By:
Merchant Equipment Store Credit Card Logos